2001 Bombardier Traxter XT XL Auto Footshift Atv Shop Manual
FILE DETAILS:
LANGUAGE:ENGLISH
PAGES:281
DOWNLOADABLE:YES
FILE TYPE:PDF
VIDEO PREVIEW OF THE MANUAL:
IMAGES PREVIEW OF THE MANUAL:
DESCRIPTION:
2001 Bombardier Traxter XT XL Auto Footshift Atv Shop Manual
This manual has been prepared as a guide to correctly service and repair 2001 ATVs. This edition was primarily published to be used by ATV mechanical technicians who are already familiar with all service procedures relating to Bombardier made vehicles. Mechanical technicians should attend continuous training courses given by Bombardier Training Department. Please note that the instructions will apply only if proper hand tools and special service tools are used.
- This shop manual uses technical terms which may be slightly different from the ones used in parts catalog. It is understood that this manual may be translated into another language. In the event of any discrepancy, the english version shall prevail.
- The content depicts parts and/or procedures applicable to the particular product at time of writing. Service and Warranty Bulletins may be published to update the content of this manual. Make sure to read and understand these.
- It does not include dealer modifications, whether authorized or not by Bombardier, after manufacturing the product. In addition, the sole purpose of the illustrations throughout the manual, is to assist identification of the general configuration of the parts.
- They are not to be interpreted as technical drawings or exact replicas of the parts. The use of Bombardier parts is most strongly recommended when considering replacement of any component. Dealer and/or distributor assistance should be sought in case of doubt.
- The engines and the corresponding components identified in this document should not be utilized on product(s) other than those mentioned in this document. Torque wrench tightening specifications must be strictly adhered to. Locking devices (ex.: locking tab, elastic stop nut, self-locking fasteners, etc.) must be installed or replaced with new ones, where specified. If the efficiency of a locking device is impaired, it must be renewed.
GENERAL INFORMATION:
- The information and component/system descriptions contained in this manual are correct at time of publication. Bombardier Inc. however, maintains a policy of continuous improvement of its products without imposing upon itself any obligation to install them on products previously manufactured.
- Due to late changes, it may have some differences between the manufactured product and the description and/or specifications in this document. Bombardier Inc. reserves the right at any time to discontinue or change specifications, designs, features, models or equipment without incurring obligation.
TABLE OF CONTENTS:
2001 Bombardier Traxter XT XL Auto Footshift Atv Shop Manual
SAFETY NOTICE III
WHAT’S NEW IV
INTRODUCTION VI
01 SERVICE TOOLS AND
SERVICE PRODUCTS
01 – Table of contents 01-01-1
02 – Service tools 01-02-1
03 – Service products 01-03-1
02 MAINTENANCE 01 – Table of contents 02-01-1
02 – Maintenance chart 02-02-1
03 – Maintenance/lubrication 02-03-1
04 – Storage/pre-season preparation 02-04-1
03 ENGINE 01 – Table of contents 03-01-1
02 – Removal and installation 03-02-1
03 – Cooling system 03-03-1
04 – Rewind starter 03-04-1
05 – Magneto system 03-05-1
06 – Cylinder and head 03-06-1
07 – Crankshaft/balancer shaft 03-07-1
08 – Lubrication system 03-08-1
09 – Clutch 03-09-1
10 – Transmission 03-10-1
04 FUEL SYSTEM 01 – Table of contents 04-01-1
02 – Fuel circuit 04-02-1
03 – Carburetor and fuel pump 04-03-1
04 – Air intake silencer 04-04-1
05 ELECTRICAL 01 – Table of contents 05-01-1
02 – Overview 05-02-1
03 – Charging system 05-03-1
04 – Starting system 05-04-1
05 – Ignition system 05-05-1
06 – Electric shift system 05-06-1
07 – Instruments and accessories 05-07-1
06 DRIVE TRAIN 01 – Table of contents 06-01-1
02 – Front drive 06-02-1
03 – Rear axle 06-03-1
07 STEERING/CONTROL
SYSTEMS
01 – Table of contents 07-01-1
02 – Steering/control systems 07-02-1
08 SUSPENSION 01 – Table of contents 08-01-1
02 – Front suspension 08-02-1
03 – Rear suspension 08-03-1
TABLE OF CONTENTS
II VMR2001_032_00_02AFM
09 BRAKES 01 – Table of contents 09-01-1
02 – Hydraulic brakes 09-02-1
10 BODY/FRAME 01 – Table of contents 10-01-1
02 – Body 10-02-1
03 – Frame 10-03-1
11 TECHNICAL DATA 01 – SI metric information guide 11-01-1
02 – Engine and vehicle 11-02-1
12 WIRING DIAGRAMS 01 – Wiring diagrams 12-01-1
PLEASE NOTE:
- This is the SAME exact manual used by your dealers to fix your vehicle.
- The same can be yours in the next 2-3 mins as you will be directed to the download page immediately after paying for the manual.
- Any queries / doubts regarding your purchase, please feel free to contact [email protected]
